WB系列微型摆线减速机

供应参数

供应价格

品牌: 枫信

产地: 上海

规格: WB系列微型摆线减速机

电议

马上订购

供应详情

一、WB系列微型摆线减速机产品特点：
1、WB系列微型摆线减速机采用高速比和高效率单级传动，就能达到1：87的减速比，效率在90％以上，如果采用多级传动，减速比更大。
　2、结构紧凑体积小由于采用了行星传动减速机原理，输入轴输出轴在同一轴心线上，使其机型获得尽可能小的尺寸。
　3、运转平稳噪声低摆线针齿啮合齿数较多，重叠系数大以及具有机件平衡的机理，使振动和嗓声限制在最小程度。
　4、使用可靠、寿命长因主要零件采用高碳铬钢材料，经淬火处理（HRC58～62）获得高强度，并且，部分传动接触采用了滚动摩擦，所以经久耐用寿命长。
5、设计合理，维修方便，容易分解安装，最少零件个数以及简单的润滑，使摆线针轮减速机深受用户的信赖。

二、WB系列微型摆线减速机使用范围：
WB系列微型摆线针轮减速机原理是依照少齿差行星传动原理，摆线针齿啮合实现减速的一种机械。该机分卧式、立式、双轴型和直联型等装配方式，是冶金、矿山、建筑、化工、纺织、轻工业等行业的首选设备。

三、WB系列微型摆线针轮减速机机型号、减速比及其表示方法：
1、单级减速机速比机型有WB65型、WB85型、WB100型、WB120型、WB150型;
     减速比分别有9、11、17、23、29、35、43、59、71、87。
   2、双级减速比机型有WBE1065型、WBE1285、WBE1510型;
    减速比分别有121、187、289、385、473、595、731、989、1225、1849。

四、摆线针轮减速机安装、维护及润滑油的更换注意事项

摆线针轮减速机安装、维护及润滑油的更换注意事项适用于以下产品：
WB系列微型摆线减速机、X系列摆线针轮减速机

a、摆线针轮减速机基本介绍：(了解摆线针轮减速机原理)
1.行星摆线针轮减速机适用于24小时连续工作制，并允许正反向运转。
2.单级摆线减速机的输出轴转向与输入轴转向相反，双级减速机的输出轴转向与输入轴转向相同。
3.摆线针轮减速机无自锁作用。
4.摆线针轮减速机的输出轴不能承受轴向力。
5.在可能出现过载现象的使用场合，应安装过载保护装置。

b、摆线针轮减速机安装注意事项：
1.脚板式卧装摆线针轮减速机要安装在没有振动、十分坚固的水平基础上，在必须进行倾斜安装的使用场合，减速机轴心线的倾斜度不得大于±15°。
2.法兰式立装摆线针轮减速机在安装时，输出轴垂直向下。
3.如需要采用除脚板式卧装和法兰式立装以外的其他特殊安装形式，必须采取相应的润滑和密封措施来保证减速机润滑充足和防止漏油。请与我厂技术部门联系。
4.采用油脂润滑的摆线针轮减速机安装角度自由。
5.摆线针轮减速机安装时，可用垫块进行调整，垫块在高度方向不超过三块，也可用楔铁进行调整，但减速校准后必须换入平垫块。
6.在冲击、振动较大或起动频繁的使用场合，机座与基础除用底脚螺栓进行联接之外，还需要用定位销（自备）进行加固。
7.标准型摆线针轮减速机的输入轴和输出轴的轴伸形式为圆柱形，采用普通平键联接。轴径尺寸公差根号h6。普通平键尺寸按GB1096-79《普通平键型式尺寸》的规定。连接法兰止口按GB1801-79的（h9)配合。
8.当采用联轴器把摆线针轮减速机与相配套的机械联接时，推荐用弹性联轴器。
9.摆线针轮减速机与想配套机械用联轴器联接时，两者轴心线的同心度不得超过联轴器所允许的范围。
10.当摆线针轮减速机与齿轮、链轮相联接时，必须保证两者轴心线的平行度。
11.当使用链轮来进行传动时，不要把齿链放得过松，否则在起动时会产生冲击力,减速机交易网。
12.当把联轴器、齿轮、链轮等联接件联接摆线针轮减速机的输出轴时，不得采用直接锤击的方法，应利用轴伸端螺孔旋入螺栓，通过压板压入。
13.安装后的摆线针轮减速机，正式使用前必须进行试运转。在空载运转正常的情况下，再逐渐加载运转。

c、摆线针轮减速机润滑通常分为指润滑和油润滑:
1、摆线针轮减速机脂润滑
     1).摆线针轮减速机单级l#～4#双级42#采用油脂润滑。 (推荐使用二硫化钼-2或ZL-2锂基润滑脂等油脂)
     2).脂的补充，在摆线针轮减速机运转时，拧下针齿壳的通气帽．用黄油枪从通气帽孔中压入润滑脂。
     3).润滑脂的注入量为摆线针轮减速机内脏晷积的1/3-1/2．油脂不宜加得过多．以避免产生搅拌热。

2、摆线针轮减速机油润滑
     1).摆线针轮减速机在使用前必须注入润滑油、出厂时的减速机为了便于装卸和运输．一般都不注入润滑油。
     2).普通用途的摆线针轮减速机．在常温下推荐使用N150极压工业齿轮油。
     3).当摆线针轮减速机在工作条件恶劣、启动停止频繁和高温或低温场合中工作时，应与厂家技术部门联系．
     4).加注润滑油时，油位高度压在油标或示油器的居中位置。

d、摆线针轮减速机润滑油油更换注意事项
    1.润滑油更换周期：摆线针轮减速机在初次运转200小时后须进行第一次更换润滑油，更换时应去残存圬油。初次换油后,
    2.以后每天连续工作lO个小时以上的减速机．应每隔3个月更换一次润滑油、每天工作不超过10个小时的减速机，应每隔6个月更换一次润滑油。
    3.己长期没有使用的减速机(一般在12个月以上)在重新使用前，必须更换润滑油。
    4.加油时旋开摆线针轮减速机上部的通气帽可加油．放油时旋开摆线针轮减速机下部的油螺塞可放出污油；
    5.不允许注入不清洁或带腐蚀性的润滑油。
    6.采用循环润滑法兰式工装摆线针轮减速机，在使用前应先启动油泵．待油泵正常工作后再启动摆线针轮减速机.

e、摆线针轮减速机相关产品：
WB系列微型摆线减速机
X系列摆线针轮减速机

五、WB系列微型摆线减速机型号表示：
WB系列微型摆线减速机型号

WB系列微型摆线减速机产品信息
WB120-WD59-370 WB100-LD17-370 WB65-WD29-120W WB1065-WD187 WB100-WD23 WB85-LD11-180W
WB120-LD35-0.75 WB85-LD35-370W WB120-LD17-1.1KW WB85-LD17-180W WB100-WD43-250W WB120-WY71-0.75-B31
WB120-LD17 WB65-WD29-120W WB100-WD23 WB85-LD17-180W WB100-WD23-750W WB120-LY11-90B5
WBE1285-LD121-0.37KW WB1510-WD289-0.75 WB85-WD43-YVP0.18 WB85-LD11-180W WB100-WD23 WB65-WD29-120W
WBE1510-WY1225-0.55 WB100-WD59-0.37 WB100-LD17-250W WB85-LD17-180W WB100-LD17-250W WB85-LD17-180W
WB120-LD35-0.75 WB100-WD23 WB100-WD59-370 WB120-WY17-80B5 WB100-WD23 WB100-LD17-250
WB85-LD17-180 WBE1285-WD1849-0.37 WBE1510-WD-1849-550 WBE1510-WD-1225-550 WBE1510-WD-989-550 WBE1510-WD-731-550
WBE1510-WD-595-550 WBE1510-WD-473-550 WBE1510-WD-385-550 WBE1510-WD-289-550 WBE1510-WD-187-550 WBE1510-WD-121-550
WBE1510-WD-1849-370 WBE1510-WD-1225-370 WBE1510-WD-989-370 WBE1510-WD-731-370 WBE1510-WD-595-370 WBE1510-WD-473-370
WBE1510-WD-385-370 WBE1510-WD-289-370 WBE1510-WD-187-370 WBE1510-WD-121-370 WBE1510-WD-1849-250 WBE1510-WD-1225-250
WBE1510-WD-989-250 WBE1510-WD-731-250 WBE1510-WD-595-250 WBE1510-WD-473-250 WBE1510-WD-385-250 WBE1510-WD-289-250
WBE1510-WD-187-250 WBE1510-WD-121-250 WBE1510-WD-1849-180 WBE1510-WD-1225-180 WBE1510-WD-989-180 WBE1510-WD-731-180
WBE1510-WD-595-180 WBE1510-WD-473-180 WBE1510-WD-385-180 WBE1510-WD-289-180 WBE1510-WD-187-180 WBE1510-WD-121-180
WBE1285-WD-1849-250 WBE1285-WD-1225-250 WBE1285-WD-989-250 WBE1285-WD-731-250 WBE1285-WD-595-250 WBE1285-WD-473-250
WBE1285-WD-385-250 WBE1285-WD-289-250 WBE1285-WD-187-250 WBE1285-WD-121-250 WBE1285-WD-1849-180 WBE1285-WD-1225-180
WBE1285-WD-989-180 WBE1285-WD-731-180 WBE1285-WD-595-180 WBE1285-WD-473-180 WBE1285-WD-385-180 WBE1285-WD-289-180
WBE1285-WD-187-180 WBE1285-WD-121-180 WBE1285-WD-1849-120 WBE1285-WD-1225-120 WBE1285-WD-989-120 WBE1285-WD-731-120
WBE1285-WD-595-120 WBE1285-WD-473-120 WBE1285-WD-385-120 WBE1285-WD-289-120 WBE1285-WD-187-120 WBE1285-WD-121-120
WBE1285-WD-1849-90 WBE1285-WD-1225-90 WBE1285-WD-989-90 WBE1285-WD-731-90 WBE1285-WD-595-90 WBE1285-WD-473-90
WBE1285-WD-385-90 WBE1285-WD-289-90 WBE1285-WD-187-90 WBE1285-WD-121-90 WBE1065-WD-1849-120 WBE1065-WD-1225-120
WBE1065-WD-989-120 WBE1065-WD-731-120 WBE1065-WD-595-120 WBE1065-WD-473-120 WBE1065-WD-385-120 WBE1065-WD-289-120
WBE1065-WD-187-120 WBE1065-WD-121-120 WBE1065-WD-1849-90 WBE1065-WD-1225-90 WBE1065-WD-989-90 WBE1065-WD-731-90
WBE1065-WD-595-90 WBE1065-WD-473-90 WBE1065-WD-385-90 WBE1065-WD-289-90 WBE1065-WD-187-90 WBE1065-WD-121-90
WBE1065-WD-1849-60 WBE1065-WD-1225-60 WBE1065-WD-989-60 WBE1065-WD-731-60 WBE1065-WD-595-60 WBE1065-WD-473-60
WBE1065-WD-385-60 WBE1065-WD-289-60 WBE1065-WD-187-60 WBE1065-WD-121-60 WBE1065-WD-1849-40 WBE1065-WD-1225-40
WBE1065-WD-989-40 WBE1065-WD-731-40 WBE1065-WD-595-40 WBE1065-WD-473-40 WBE1065-WD-385-40 WBE1065-WD-289-40
WBE1065-WD-187-40 WBE1065-WD-121-40 WBE1510 WBE1285 WBE1065 WB150-L1D-71-1500
WB150-L1D-59-1500 WB150-L1D-47-1500 WB150-L1D-43-1500 WB150-L1D-35-1500 WB150-L1D-29-1500 WB150-L1D-23-1500
WB150-L1D-17-1500 WB150-L1D-11-1500 WB150-L1D-9-1500 WB150-L1D-71-1100 WB150-L1D-59-1100 WB150-L1D-47-1100
WB150-L1D-43-1100 WB150-L1D-35-1100 WB150-L1D-29-1100 WB150-L1D-23-1100 WB150-L1D-17-1100 WB150-L1D-11-1100
WB150-L1D-9-1100 WB150-L1D-71-750 WB150-L1D-59-750 WB150-L1D-47-750 WB150-L1D-43-750 WB150-L1D-35-750
WB150-L1D-29-750 WB150-L1D-23-750 WB150-L1D-17-750 WB150-L1D-11-750 WB150-L1D-9-750 WB120-L1D-71-750
WB120-L1D-59-750 WB120-L1D-47-750 WB120-L1D-43-750 WB120-L1D-35-750 WB120-L1D-29-750 WB120-L1D-23-750
WB120-L1D-17-750 WB120-L1D-11-750 WB120-L1D-9-750 WB120-L1D-71-550 WB120-L1D-59-550 WB120-L1D-47-550
WB120-L1D-43-550 WB120-L1D-35-550 WB120-L1D-29-550 WB120-L1D-23-550 WB120-L1D-17-550 WB120-L1D-11-550
WB120-L1D-9-550 WB120-L1D-71-370 WB120-L1D-59-370 WB120-L1D-47-370 WB120-L1D-43-370 WB120-L1D-35-370
WB120-L1D-29-370 WB120-L1D-23-370 WB120-L1D-17-370 WB120-L1D-11-370 WB120-L1D-9-370 WB100-L1D-71-750
WB100-L1D-59-750 WB100-L1D-47-750 WB100-L1D-43-750 WB100-L1D-35-750 WB100-L1D-29-750 WB100-L1D-23-750
WB100-L1D-17-750 WB100-L1D-11-750 WB100-L1D-9-750 WB100-L1D-71-550 WB100-L1D-59-550 WB100-L1D-47-550
WB100-L1D-43-550 WB100-L1D-35-550 WB100-L1D-29-550 WB100-L1D-23-550 WB100-L1D-17-550 WB100-L1D-11-550
WB100-L1D-9-550 WB100-L1D-71-370 WB100-L1D-59-370 WB100-L1D-47-370 WB100-L1D-43-370 WB100-L1D-35-370
WB100-L1D-29-370 WB100-L1D-23-370 WB100-L1D-17-370 WB100-L1D-11-370 WB100-L1D-9-370 WB100-L1D-71-250
WB100-L1D-59-250 WB100-L1D-47-250 WB100-L1D-43-250 WB100-L1D-35-250 WB100-L1D-29-250 WB100-L1D-23-250
WB100-L1D-17-250 WB100-L1D-11-250 WB100-L1D-9-250 WB100-L1D-71-180 WB100-L1D-59-180 WB100-L1D-47-180
WB100-L1D-43-180 WB100-L1D-35-180 WB100-L1D-29-180 WB100-L1D-23-180 WB100-L1D-17-180 WB100-L1D-11-180
WB100-L1D-9-180 WB85-L1D-71-250 WB85-L1D-59-250 WB85-L1D-47-250 WB85-L1D-43-250 WB85-L1D-35-250
WB85-L1D-29-250 WB85-L1D-23-250 WB85-L1D-17-250 WB85-L1D-11-250 WB85-L1D-9-250 WB85-L1D-71-180
WB85-L1D-59-180 WB85-L1D-47-180 WB85-L1D-43-180 WB85-L1D-35-180 WB85-L1D-29-180 WB85-L1D-23-180
WB85-L1D-17-180 WB85-L1D-11-180 WB85-L1D-9-180 WB85-L1D-71-120 WB85-L1D-59-120 WB85-L1D-47-120
WB85-L1D-43-120 WB85-L1D-35-120 WB85-L1D-29-120 WB85-L1D-23-120 WB85-L1D-17-120 WB85-L1D-11-120
WB85-L1D-9-120 WB85-L1D-71-90 WB85-L1D-59-90 WB85-L1D-47-90 WB85-L1D-43-90 WB85-L1D-35-90
WB85-L1D-29-90 WB85-L1D-23-90 WB85-L1D-17-90 WB85-L1D-11-90 WB85-L1D-9-90 WB65-L1D-71-60
WB65-L1D-59-60 WB65-L1D-47-60 WB65-L1D-43-60 WB65-L1D-35-60 WB65-L1D-29-60 WB65-L1D-23-60
WB65-L1D-17-60 WB65-L1D-11-60 WB65-L1D-9-60 WB65-L1D-71-90 WB65-L1D-59-90 WB65-L1D-47-90
WB65-L1D-43-90 WB65-L1D-35-90 WB65-L1D-29-90 WB65-L1D-23-90 WB65-L1D-17-90 WB65-L1D-11-90
WB65-L1D-9-90 WB150-LD-71-1500 WB150-LD-59-1500 WB150-LD-47-1500 WB150-LD-43-1500 WB150-LD-35-1500
WB150-LD-29-1500 WB150-LD-23-1500 WB150-LD-17-1500 WB150-LD-11-1500 WB150-LD-9-1500 WB150-LD-71-1100
WB150-LD-59-1100 WB150-LD-47-1100 WB150-LD-43-1100 WB150-LD-35-1100 WB150-LD-29-1100 WB150-LD-23-1100
WB150-LD-17-1100 WB150-LD-11-1100 WB150-LD-9-1100 WB150-LD-71-750 WB150-LD-59-750 WB150-LD-47-750
WB150-LD-43-750 WB150-LD-35-750 WB150-LD-29-750 WB150-LD-23-750 WB150-LD-17-750 WB150-LD-11-750
WB150-LD-9-750 WB120-LD-71-750 WB120-LD-59-750 WB120-LD-47-750 WB120-LD-43-750 WB120-LD-35-750
WB120-LD-29-750 WB120-LD-23-750 WB120-LD-17-750 WB120-LD-11-750 WB120-LD-9-750 WB120-LD-71-550
WB120-LD-59-550 WB120-LD-47-550 WB120-LD-43-550 WB120-LD-35-550 WB120-LD-29-550 WB120-LD-23-550
WB120-LD-17-550 WB120-LD-11-550 WB120-LD-9-550 WB120-LD-71-370 WB120-LD-59-370 WB120-LD-47-370
WB120-LD-43-370 WB120-LD-35-370 WB120-LD-29-370 WB120-LD-23-370 WB120-LD-17-370 WB120-LD-11-370
WB120-LD-9-370 WB100-LD-71-750 WB100-LD-59-750 WB100-LD-47-750 WB100-LD-43-750 WB100-LD-35-750
WB100-LD-29-750 WB100-LD-23-750 WB100-LD-17-750 WB100-LD-11-750 WB100-LD-9-750 WB100-LD-71-550
WB100-LD-59-550 WB100-LD-47-550 WB100-LD-43-550 WB100-LD-35-550 WB100-LD-29-550 WB100-LD-23-550
WB100-LD-17-550 WB100-LD-11-550 WB100-LD-9-550 WB100-LD-71-370 WB100-LD-59-370 WB100-LD-47-370
WB100-LD-43-370 WB100-LD-35-370 WB100-LD-29-370 WB100-LD-23-370 WB100-LD-17-370 WB100-LD-11-370
WB100-LD-9-370 WB100-LD-71-250 WB100-LD-59-250 WB100-LD-47-250 WB100-LD-43-250 WB100-LD-35-250
WB100-LD-29-250 WB100-LD-23-250 WB100-LD-17-250 WB100-LD-11-250 WB100-LD-9-250 WB100-LD-71-180
WB100-LD-59-180 WB100-LD-47-180 WB100-LD-43-180 WB100-LD-35-180 WB100-LD-29-180 WB100-LD-23-180
WB100-LD-17-180 WB100-LD-11-180 WB100-LD-9-180 WB85-LD-71-250 WB85-LD-59-250 WB85-LD-47-250
WB85-LD-43-250 WB85-LD-35-250 WB85-LD-29-250 WB85-LD-23-250 WB85-LD-17-250 WB85-LD-11-250
WB85-LD-9-250 WB85-LD-71-180 WB85-LD-59-180 WB85-LD-47-180 WB85-LD-43-180 WB85-LD-35-180
WB85-LD-29-180 WB85-LD-23-180 WB85-LD-17-180 WB85-LD-11-180 WB85-LD-9-180 WB85-LD-71-120
WB85-LD-59-120 WB85-LD-47-120 WB85-LD-43-120 WB85-LD-35-120 WB85-LD-29-120 WB85-LD-23-120
WB85-LD-17-120 WB85-LD-11-120 WB85-LD-9-120 WB85-LD-71-90 WB85-LD-59-90 WB85-LD-47-90
WB85-LD-43-90 WB85-LD-35-90 WB85-LD-29-90 WB85-LD-23-90 WB85-LD-17-90 WB85-LD-11-90
WB85-LD-9-90 WB65-LD-71-60 WB65-LD-59-60 WB65-LD-47-60 WB65-LD-43-60 WB65-LD-35-60
WB65-LD-29-60 WB65-LD-23-60 WB65-LD-17-60 WB65-LD-11-60 WB65-LD-9-60 WB65-LD-71-90
WB65-LD-59-90 WB65-LD-47-90 WB65-LD-43-90 WB65-LD-35-90 WB65-LD-29-90 WB65-LD-23-90
WB65-LD-17-90 WB65-LD-11-90 WB65-LD-9-90 WB150-WD-71-1500 WB150-WD-59-1500 WB150-WD-47-1500
WB150-WD-43-1500 WB150-WD-35-1500 WB150-WD-29-1500 WB150-WD-23-1500 WB150-WD-17-1500 WB150-WD-11-1500
WB150-WD-9-1500 WB150-WD-71-1100 WB150-WD-59-1100 WB150-WD-47-1100 WB150-WD-43-1100 WB150-WD-35-1100
WB150-WD-29-1100 WB150-WD-23-1100 WB150-WD-17-1100 WB150-WD-11-1100 WB150-WD-9-1100 WB150-WD-71-750
WB150-WD-59-750 WB150-WD-47-750 WB150-WD-43-750 WB150-WD-35-750 WB150-WD-29-750 WB150-WD-23-750
WB150-WD-17-750 WB150-WD-11-750 WB150-WD-9-750 WB120-WD-71-750 WB120-WD-59-750 WB120-WD-47-750
WB120-WD-43-750 WB120-WD-35-750 WB120-WD-29-750 WB120-WD-23-750 WB120-WD-17-750 WB120-WD-11-750
WB120-WD-9-750 WB120-WD-71-550 WB120-WD-59-550 WB120-WD-47-550 WB120-WD-43-550 WB120-WD-35-550
WB120-WD-29-550 WB120-WD-23-550 WB120-WD-17-550 WB120-WD-11-550 WB120-WD-9-550 WB120-WD-71-370
WB120-WD-59-370 WB120-WD-47-370 WB120-WD-43-370 WB120-WD-35-370 WB120-WD-29-370 WB120-WD-23-370
WB120-WD-17-370 WB120-WD-11-370 WB120-WD-9-370 WB100-WD-71-750 WB100-WD-59-750 WB100-WD-47-750
WB100-WD-43-750 WB100-WD-35-750 WB100-WD-29-750 WB100-WD-23-750 WB100-WD-17-750 WB100-WD-11-750
WB100-WD-9-750 WB100-WD-71-550 WB100-WD-59-550 WB100-WD-47-550 WB100-WD-43-550 WB100-WD-35-550
WB100-WD-29-550 WB100-WD-23-550 WB100-WD-17-550 WB100-WD-11-550 WB100-WD-9-550 WB100-WD-71-370
WB100-WD-59-370 WB100-WD-47-370 WB100-WD-43-370 WB100-WD-35-370 WB100-WD-29-370 WB100-WD-23-370
WB100-WD-17-370 WB100-WD-11-370 WB100-WD-9-370 WB100-WD-71-250 WB100-WD-59-250 WB100-WD-47-250
WB100-WD-43-250 WB100-WD-35-250 WB100-WD-29-250 WB100-WD-23-250 WB100-WD-17-250 WB100-WD-11-250